|
#1
|
|||
|
|||
Intermittent starting problem (warmish engine)
Hi,
Have been quiet on here, this is my first ever post on a forum so bear with me I have owned my 1991 940TD since August and apart from a new battery has got through a very wet winter with no problems. But in the last couple of weeks has been playing up a bit: Apart from all the smoke and clattering she starts from cold okay but after driving and reaching running temp when left for a little bit (30 - 60 mins) she doesn't always start, just turns over. Often the glow plug relay sounds like it is clicking back and forth. If anybody has any advice or information I would be very grateful. Thanks in advance Jason |
#2
|
|||
|
|||
If cold start is not smooth, you cold be looking at an ailing seal introducing air, or one glow plug failed...check fuel return line for bubbles.
I've also seen a few older injection pumps do that, and falsely triggering the glow plugs for a few seconds seem to work around the issue. As a quick check, when you are having the issue, use a short U of #10 or bigger wire to jump the 2 big terminals on the glow relay, count to 10, and have a go at starting the car. Also if you have some type of primer pump, prime and try to start...if fixed air leak in fuel supply. |
#3
|
|||
|
|||
Hi, thanks for the info, i will try that next time!
|
#4
|
|||
|
|||
Happened again today :-S Definitely seems to be a problem occurring when the engine is warm; wouldn't start after a 30min journey. We just left it, went for a walk, had a cup of tea and cake, came back and she started :-) Mind you i think it was about 3 hours!!
|
#5
|
|||
|
|||
Low compression?
So-- back to square one? Starts reliably when cold, starts OK when hot but not warm (after sitting 30-60 minutes)?
Low compression unfortunately can cause this. But you can "workaround" it for quite a while by forcing the GPs to energize when the engine is warm to help a low-compression start. Simply disconnect the temp sensor for the GPs. It's the sensor at the rear of the head, almost underneath the rear camshaft cogged sprocket. This will fool the GP brain into thinking it is massively cold each time you turn the ignition key from off to on, and give max time for the GPs. You will soon get the hang of how much time to let the GPs sizzle before a warm start. NOTE: This will tend to wear out the GPs sooner than normal.
__________________
1985 744 gle d24t 1985 745 gle d24t |
#6
|
|||
|
|||
Hi Ngoma, thanks for the info. I díd vaguely remember something about the temp sensor, but in the middle of the car park with my little son getting fed up in the back couldn't see it! :$ i'm putting in new gp's today well hopefully....
|
Tags |
glow plugs, relay, starting |
|
|